check engine light BMW MOTORRAD R 850 R 2004 Rider's Manual (in English)

i
2
Introduction
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Trip meter/clock .................. 10
Hazard warning flashers ...... 11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Seat/helmet holder .............. 14
Seats ............................. 15-16
System case .................. 17-19Safety check
Checklist ........................ 20-21
Engine oil ....................... 22-23
Fuel ................................ 24-25
Handlebar levers ............ 26-27
Brake system -
general........................... 28-29
Brake system - without
BMW Integral ABS ......... 30-32
Brake system - with
BMW Integral ABS ......... 33-36
Clutch ................................. 37
Lights ............................. 38-40
Shock-absorber
adjustment .......................... 41
Suspension
spring preload ..................... 42
Wheels ........................... 43-44
Accessories and loads ... 45-47
Contents
10r28bkg3.book Seite 2 Dienstag, 25. Mai 2004 5:26 17

2
21
2
Safety check
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar-lever fittings
– Brake fluid level
– Clutch fluid level
–Brakes
– Warning lights and telltale lights
–Lights
– Shock-absorber setting and spring preload
– Condition of wheels and
tyres, tread depth and tyre
pressures
– Load, gross weight – Check at regular intervals as
described in the following
sections
(each time you stop for refuel-
ling):
– Engine oil level
(every second or third time
you stop for refuelling):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
Motorrad dealer.
He will provide the necessary
advice and assistance.
Checklist
10r2802g3.fm Seite 21 Donnerstag, 3. Juni 2004 11:29 11

2
23
2
Safety check
MAXMIN1
2
 Check oil level at sight glass: MAX Upper edge
Ring marking
MIN Lower edge
Ring marking
– The difference between the two marks is approx. 0.5 litres
 If necessary, unscrew the oil filler screw 2 and top up the
engine oil through the engine
oil filler 1
 Then retighten the oil filler
screw 2
e Attention:
Warning light, engine oil pres-
sure red
p (b 7) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10r2802g3.fm Seite 23 Donnerstag, 3. Juni 2004 11:29 11

33
62
Starting – Riding – Parking
1234*
5
Fuel levelWhen the warning light1
comes on, there are still
approx. 5 litres of fuel in the
tank.
Engine oil pressureWarning light 2 goes out above
idle speed.
* depending on national-market speci-
fication
e Attention:
If warning light 2 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
 Operate the kill switch
 Bring the motorcycle safely to a halt
 Check engine oil level (
b 22)
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Telltale and warning lights
10r28bkg3.book Seite 62 Dienstag, 25. Mai 2004 5:26 17

i
84
Index
AActive brake with ABSchanging brake fluid, 33
checking brake fluid level, 33
Anti-lock braking system notes, 68, 70-75
BBrake fluid
changing, 30
Brake fluid level
checking, 30
checking front, 31, 35
checking rear, 32, 36
Brake pads, checking, 29
Brake system checking, 28
general, 28, 29
with BMW Integral ABS, 33-36
without BMW Integral ABS, 30,
31, 32
Braking, precautions, 66
C
Capacity, 25
Catalytic converter, 51 safety instructions, 51
Centre stand, 54, 55
Checking brake fluid level, 30
Choke
cold start, 12, 61
Choke lever operation, 61
position, 12 Clock (in cockpit), 10
Closing the System case, 18
Clutch
fluid level, 37
lever, 26
Cockpit layout, 6
DDipswitch, 12
EEngine oil, 22 filler, 4, 23
level sight glass, 4
pressure warning light, 62
FFront brake
brake fluid level, 31, 35
brake fluid reservoir, 5
lever, 27
Fuel, 24 filler cap, 5
octane number, 25
refuelling, 24
Fuse box, 5
GGear shifts, 64, 65
General view
left side, 4
right side, 5
A - G
10r28bkg3.book Seite 84 Dienstag, 25. Mai 2004 5:26 17

i
85
Index
HHandlebar fittingleft, 12
right, 13
Handlebar levers, 26 clutch, 26
handbrake, 27
Hazard warning flashers, 11
Headlight beam throw adjustment, 38
Heated handlebar grips, 11, 13
Helmet holder, 14
High/low (dipped) headlight
switch, 12
Horn, 12
Hydraulic fluid clutch, 37
IIgnition switch and steering lock, 6
function, 8, 9
Ignition, switching on, 58, 59
Installing System case, 19
Instruments, 6
KKill switch, 13
LLight
general instructions, 38
headlight beam throw, 38
switch, 13
MMotorcycle equipment, 81
NNeutral, 59
OOctane number (fuel), 25
Odometer, 6
Oil filler, engine, 4, 22
Oil levelchecking, 22
engine oil pressure, 7, 62
sight glass, 4
Opening the System case, 17
Overheating, 60
PPower socket, 12 V, 4
RRear brake brake fluid reservoir, 5
Removing System case, 18
Residual braking, 34
Rev. counter, 6
Rider’s equipment, 80
Riding, 64
Running in, 57
H - R
10r28bkg3.book Seite 85 Dienstag, 25. Mai 2004 5:26 17

i
86
Index
SSafety check, 20
Safety instructionscatalytic converter, 51
general, 50, 51
Seat, 16
adjusting, 14, 15
closing the storage
compartment, 16
lock, 5
single, 16
Service worldwide, 78
Shock absorbers, 41
Side stand, 52, 53
Speedometer, 6
Spring preload, front, 42
Spring strut, 4
Starter button, 13
Starting the engine, 60
Storage compartment, 16
Storage-compartment cover, 16
System case, 17, 18, 19
T
Telltale lights ABS, 7, 63
battery charge, 7, 63
engine oil pressure, 7, 62
fuel tank level, 7, 62
high-beam headlights, 7
left turn indicator, 7
neutral, 7
right turn indicator, 7
Toolkit, 5, 16 Tread depth, tyres, 43
Trip meter, 6
Turn indicator switch
left, 12
right, 13
Turn indicators
telltale lights, 7
Turn-indicator cancel switch, 13
Type plate, 5
Tyre pressures, 44
Tyre valve caps, 43
Tyres running-in, 57
VValve caps, 43
WWarning lights
ABS, 7, 63
battery charge, 7, 63
engine oil pressure, 7, 62
fuel tank content, 7, 62
general, 7, 63
Wheels, 43
S - Z
10r28bkg3.book Seite 86 Dienstag, 25. Mai 2004 5:26 17